stator upgrade-can I? - Harley Davidson Forums Yes, you must replace the entire stator, rotor and regulator Harley sells a 32 amp Upgrade kit Part number 29985-87 retails for 239 95 It is for 1984-88 and stock on all 1989-95 and some 96, 97 I have used the Harley kit on my 1985 FLHT before I sold it It was complete and easy to install These are complete kits listed in a J P catalog I have They are for use on your year FL I only
Stator Output - Harley Davidson Forums Hi All, I have a question concerning the stator output on a 2005 Ultra Classic I noticed on my last ride the volt meter did not move off of 12 volts I hooked up my meter and got no reading over 12 volts regardless of engine RPM Should be around 14 to 14 5 volts or so Battery is almost
Possible grounding problem???? | Harley Davidson Forums I have a95 FLT Ultra Classic that has been a project bike for two years I have had a problem with the charging system and finally found out whoever put the last stator in tore the boot that goes through the engine housing Dead short for who knows how long Replaced the stator and regulator and
radio static - Harley Davidson Forums The mechancs kept saying that it's an alternator stator problem Wrong I can cruising down the road, squeeze the clutch, turn the engine off, and the static continues until the bike slowly comes to a stop The static decreases in relation to the slowing speed
Stator Gone Bad | Harley Davidson Forums The stator in my old bike, 04 UC, had to be replaced at 35k miles I was using Screaming Eagle HD oil at that time in all three holes and changed it every 5k miles
Charging System Test For Older Evo models and TC Models | Harley . . . Test your stator and regulator again Is the wiring stock? Any aftermarket electric items on the bike? Also, what model is it? FX, FLH? Also, if the new battery is low on charge it will drag the system down What is the voltage when you are rev'ing to about 2000 rpm?
08 FLHX Voltage Reg Output | Harley Davidson Forums 4 Stator Checks Rotor Check: Each of the following tests isolate the stator Rotor, If AC Output test Fails and Resistance Check, and Stator IB Test Pass then Rotor is at fault (Pull Primary covers and inspect rotor for damage) AC Output Check: Unplug the regulator plug from the stator Start motorcycle and change Voltmeter to AC volts
Stator wiring - Harley Davidson Forums The wiring diagram shows three black wires going from the Stator to three black wires coming from the voltage regulator It does not put them in any order What does the Stator do? Do all three wires from the stator do the same thing, supply current to the voltage regulator They all look like they are hooked up to the Stator the same way
stator plug leaking. . . | Harley Davidson Forums I have a 2004 Road King and have recently noticed the stator plug is leaking a little primary fluid-just a drop or 2 on the ground after a short ride I put new crank seal in and replaced the stator maybe 4 or 5 months ago The oil from the engine isn't overfilling the primary Is there a way to